KitchenAid 740-0781 Instruction Manual download pdf (Page 5)

INST

ALLA

TION R

QUIREMENTS

Tools and Parts

Gather the required

tools and parts before starting installation. Read and

follow the instructions provided with any tools listed here.

Tools Needed

Parts Supplied

Gas pressure regulator/hose assembly set for 1

1" WCP LP gas.

1 - “AA” size alkaline battery

20 lb LP gas fuel tank tray

12 screws (for installing 20 lb LP gas fu

el tank tray, 90° brass clamp/

Natural gas regulator clamp)

Hardware packet

2 piece 90° brass clamp (for mounting 90° brass connector)

+H[ wrench (for loosening control knobs)

Warming rack

Parts Needed

20 lb LP gas fuel tank

Parts Supplied for Conversion to Natural Gas

Natural gas conversion kit (which includes):

Natural gas regulato

r (marked “Natural Gas Regulator”)

10 ft (3.0 m) PVC flexible gas supply h

ose with quick connector

6 mm nut driver

Natural gas regulato

r clamp

2.05 mm Nat

ural gas orifice for rotisserie/infrared burner

2.10 mm Natural gas orifice for infrared searing

burner

Parts Needed for Conversion to Natural Gas

Gas line shutoff valve

½" male pipe thread nipple for connection to pressure regulator.

LP gas-resistant pipe-joint compound

CSA design-certified

outdoor flexible stainless steel appliance

connector (4-5 ft [1.2-1.5 m]) or rigid gas supply line as needed.

Location Requirements

Select a

location that provides minimum exposure to wind and traffic

paths. The location should be away from strong draft areas.

Do not obstruct flow of combustion and ventilation air.

Clearance to combustible construction for outdoor grills:

A minimum of 24" (58.0 cm) must be main

tained between the front

of the grill hood, sides and back of the grill and any combustible

construction.

A 24" (58.0

cm) minimum clearance must also be maintained below

the cooking surface and any combustible construction.

Rotisserie (accessory)*

If you equip your gr

ill with a rotisserie, a 6" (15.2 cm) minimum

clearance is needed for the rotisserie motor.

A grounded, 3 prong outlet located to the left of the grill is required.

*See “Assistance” section to order.

Tape measure

Small, flat-blade screwdriver

#2 and #3

Phillips screwdriver

Level

Wrench or pliers

Pipe wre

nch

Scissors or cutting pliers 

(to re

move tiedowns)

Noncorrosive leak- detection

solution

ARNING

Explosion Hazard

Do not store fuel tank in a garage or indoor

Do not store grill with fuel tank in a garage or indoors.

Failure to follow these instructions can result in death,

explosion, or fire.

WARNING

Fire Hazard

Do not use grill near combustible materials.

Do not store combustible materials near grill.

Doing so can result in death or fire.

1 2 3 4 5 6 7 8 9 10 ... 95 96

Comments to this Manuals

No comments

KitchenAid 740-0781 Instruction Manual Page 5

Comments to this Manuals

Related products and manuals for Barbecues & grills KitchenAid 740-0781